Testing Diode -The Accurate Way on How to Test Semiconductor Diode Using Multimeter

Testing diodes is different from testing a resistor because you need a skill to do it. If you do not know or wrongly test a diode you will be unable to repair the equipment. A bad diode you think it is good. This will definitely waste your precious time.

A rectifier diode can fail in one of the four ways. It can become:

-Open
-Shorted
-Leaky
-Breakdown when in full operating voltage

An analog multimeter or digital multimeter can be used to check for all the first three conditions except the last one where the diode breakdown in full operating voltage. From my of experienced in the electronic repairing line, i found that checking diode using analog multimeter is more accurate than using a digital multimeter. I could explain to you why i preferred analog meter. I do not know about you because i really came across quite a number of diodes where it checked ok using digital multimeter but failed when test with analog meter.

The first step on how to test a diode is to remove one of the diode lead. You can't always be certain if a diode is good or bad if you perform in-circuit test, because of back circuits through other components. To be absolutely sure, you will need to lift, or disconnect, one diode lead from the circuit to avoid back circuits. Unless you are very sure about the board you are checking. Sometimes i do found bad diodes when checking it on board. Your experienced will tell you when to check a diode on-board or off-board. If you are new to electronic repair, i highly recommend that you check a diode with a lead removed from the board.

I will set my analog meter to x1 ohms to check for current diode leakage reverse and forward testing. Connecting the black probe of your meter to the cathode and red probe to the anode, the diode is reverse biased and should look like an open reading. Connecting the red probe of your meter to the cathode and black probe to the anode, the diode is forward biased and the meter should read some value of resistance. If you have two readings then most probably the diode is shorted or leaky and you should replace it. If you don't get any reading either forward or reverse bias, the diode is considered open.

The real problem when checking a diode using the diode test function of a digital meter is that an open or leaky diode, the meter sometimes reads ok(0.6). This is due to digital meter diode test output voltage (which you can measure the output test probe using another meter) is around 500mv to 2v. An analog meter set to x1 ohms have output about 3V(remember the two 1.5V battery you installed in the meter!). The 3V voltage is enough to show you the accurate reading of a diode when under test.

Even if you have a good reading at x1 ohms doesn't mean that the diode is good . You now have to set your meter to x10K to test the diode again. The output voltage of x10k ohms is about 12V(remember the 9v battery in your meter-1.5v+1.5v+9v=12v). Again the diode under test should show only one reading. This is exception to Schottky diode where it have two readings but not shorted reading. If the meter showed one reading then the diode under test is good. If it has two readings then most probably the diode is either shorted or leaky. The digital meter can't test it because the output from the meter is only 500mv to 2V.

If a diode breakdown when under full operating voltage, there is no way to testing diode (unless you have a very expensive diode checker which specially designed to locate this type of problem).Substituting with a known good diode is often the only way to prove that an intermittent diode is causing a particular problem. Sometimes an intermittent diode could be locate using a coolant spray.

Caution: Be certain that power is removed from any circuit before performing any of the following diode checks, otherwise meter or circuit damage could result.

Conclusion-In order to correctly test diode function you need to set the analog meter to x1 ohms and x10K ohms range.

Jestine Yong is a electronic repairer and a writer. For more electronic repair information please visit his website at http://www.noahtec.com/electronic-repai r-articles.htm

---

Lock Workstation Fast

When you work in an office, it's important to lock your workstation every time you step away from your computer. A pain, but a security measure. You... Read More

Printer Cartridges - Step Back in History

You are working and trying to print out important documents when you discover that you are out of ink. This would have been a big drawback in... Read More

A Review of Brother Laser Toners

Brother is right up there with HP and Samsung as one of the most sought-after brands of laser toner. The Japan-based Brother Industries was first famous for... Read More

Learn About The Three Basic Types Of Computer Mouse

1) Mechanical: This is a type of computer mouse that has a rubber or metal ball on its underside and it can roll in every direction. Sensors... Read More

Upgrading, Adding or Removing a Video Card, Sound Card, or Other AGP/PCI Card

For Video cards - Most PC video cards these days are AGP. But you COULD be working with PCI, or PCI express. If you're not sure which... Read More

Do You Feel Used by Computers?

Do You Feel Used by Computers?A look at second-user computer equipment.Let's dispense with the myths first. I'm NOT talking about the sort of second-hand computers you get... Read More

What Is A Crystal? And How To Test It

Crystal are use to keep the frequency of the clock from drifting. If the signal from this clock stops, or is weak, or the pulses begin to... Read More

Coping with a Serious Data Loss from your Computer Hard Drive

Data loss is an expensive reality. It's a hard fact that it happens more often then users like to admit. A recent study by the accounting firm... Read More

3 Easy Step To Locate A Real Bargain On Laptop Batteries

Looking for a real bargain on laptop batteries? How do I know the batteries are running good as advertised? Which merchants are offering quality rechargeable cells? Where... Read More

A Review of Refurbished Toshiba Laptops

Toshiba offers a few of their refurbished laptops in the "Clearance Store" of their official website toshibadirect.com. There you can purchase their laptops at 20-30% discounts, refurbished... Read More

RAID Disk Recovery

RAID is short for Redundant Array of Independent (or Inexpensive) Disks, a category of disk drives that employ two or more drives in combination for fault tolerance... Read More

Getting A New Laptop At A Great Price

With all the wheeling and dealing that seems to take place on the internet at all times of the day, it can sometimes get confusing just trying... Read More

Toner Cartridges - How They Work

In the past computers and their accompanying printers were huge. Toner reservoirs and toner cartridges were used instead of ink cartridges like the ones in use today.... Read More

Intel Celeron vs Pentium

The Celeron and Pentium Processors are two of Intel's best selling CPUs. They are found in a majority of home computer systems. When comparing the two processors... Read More

Purchasing Laser Toner Refills

Laser toner refills can be expensive. Over the life of the printer, expect to spend many times more on laser toner refill than you paid for the... Read More

Build Your First Computer from Hardware Scratches

Wow- if you do it first time and have some asset of time in your disposition ? then go ahead and purchase motherboard, your favorite processor, memory,... Read More

An Inexpensive Solution to Securing Public Access Computers

Offering secure public Internet access is not as easy as it may seem. As the IT manager for a mid-sized public library, it's become apparent to me... Read More

Bluetooth Can Be Cracked!

Nothing is completely safe today. Adobe has recently released a patch for a security hole in different graphical software, so why should Bluetooth be safe?... and Bluetooth... Read More

Is A Laser Printer Right For Me?

The average home computer user definitely does not need a laser printer. Sure laser printer prices have fallen considerably in the last couple of years. But have... Read More

Dell Inspiron 600m Notebook Computer

After twelve years of owning desktop computers, I finally opted for a laptop so I would no longer be chained to my desk. After months of research... Read More

ESR Meter - The Capabilities To Check Beyond Electrolytic Capacitor

There is something good about esr meter because besides electrolytic capacitor it can be use to measure other type of capacitors such as the non polarity capacitor.... Read More

Ten Tips to Safeguard Your Laptops

The following is a list of tips to help safeguard your laptop while traveling or conducting business.1. Never leave your laptop unattended. Keep your laptop in your... Read More

TiVo: An Introduction for the Few Who Dont Know Yet

TiVo will change your life... for the better. Plain and simple: record shows by telling TiVo to record them (not when, what channel, how long, etc.), record... Read More

A Review of Samsung Laser Toners

Samsung laser toner is just as popular as its Hewlett-Packard and Brother counterparts. Samsung is a group of products and services that began in Korea in 1938.... Read More

Small Computers

Today, small form factor computers demolish the myth that bigger PCs are faster. Specially designed SFF computers from Ovi PC, like the Prometheus, deliver tower-crushing performance in... Read More

How To Choose The Best Gaming Laptop

The gaming laptop is coming of age! It is steadily increasing in popularity as performance quality goes up. Gamers now regularly consider laptops or notebooks when searching... Read More